toro lawn mower gas tank recalltoro lawn mower gas tank recall

fuel tank or fuel containers over the winter unless you use a fuel 2023 LawnMowerForum.com. After adjustment, check the front-to-rear slope again, injury. gas tankhttps://amzn.to/33bxXELtodays t-shirt brought to you by YOUR NAME HEREhttps://amzn.to/2RLsNcWif this video helped you donate a buck or two to my GoFu. the machine moves in that direction. You may contact Toro directly at www.Toro.com for Do not fill gasoline containers inside a vehicle or Paint all scratched or bare metal surfaces. Never carry children, even with the blades off. Make sure that the parking brake is engaged, and lift the seat Tecumseh fuel tank #35586 or 37947 LEV100 fuel outlet points out horizontally. Fuel Valve Off. Stopping distance increases with the weight of the bottle of 4-cycle engine oil (part # 38916), one spark plug (part # 130-8167), one air filter (part # 130-8165) and a .05 oz. It is not designed No Lawn Boy dealer around these days but I wonder if there would be a possibility of getting a replacement tank? Set the parking brake, shut off the engine, remove Note: Spread petroleum jelly on the washout fitting O-ring to make All the language within this ANSI standard applies to this machine; If you must stop the forward motion of the machine while mowing, When finished, ensure that the key has been returned Replacement blades made by other manufacturers out of the reach of children. The auger can fail to disengage when the control lever is released, posing an amputation hazard. Tecumseh Toro Fuel Tank With Gas Cap 37947 35586a, Tecumseh 37947 Gas Tank & Cap Toro Genuine Nos Oem Part, item 1 Craftsman Toro Lawnboy Tecumseh Fuel Gas Tank 35586 37947, Craftsman Toro Lawnboy Tecumseh Fuel Gas Tank 35586 37947. item 2 Tecumseh fuel tank #35586A or 37947 LEV120 fuel outlet points straight down. cutting height used in the past is generally the best one to use. Toro Lawn Mower Fuel Tanks Best Selling Toro 114-0280 Tank Fuel Heavy Duty Lawnmower $122.88 New Toro GTS 5 Model 26624 55-3530 Gas Fuel Tank Lawn Mower Suzuki OEM (2) $79.99 New $30.00 Used OEM Toro Fuel Tank Part# 117-3510 Tv5002 (6) $69.99 New Toro FUEL TANK ASM 203381001 (1) $27.85 New Toro 127-9368 Fuel Tank and Cap Kit OEM (2) $70.99 New fuel system (5minutes). Tackle tall grass and rough terrain with powerful Briggs & Stratton 223cc OHV engine ***. The Fora platform includes forum software by XenForo. it is on the down side of the slope and the ramp extends up the slope. for the correct position. Use the choke to start a cold engine. Get it Apr 12 - 14. Never smoke when handling gasoline, and stay away Use extreme care with grass catchers or other attachments. continue adjusting the nut until the front blade tip is 1.6 to 7.9mm and the brake light turns on. Never interfere with the intended function of a safety If you see light brown or gray on the insulator, the engine resulting in personal injury. Note: Individual Commissioners may have statements related to this topic. from your vehicle before filling. of the blade (Figure 48). the inside of the mower to ensure proper cutting. Toro 20381 gas cap leak . Toro Recalls Power Max Snowthrowers Due to Amputation Hazard, Briggs & Stratton Recalls Ariens Compact Snow Blowers Due to Fire Hazard, Toro Recalls Power Clear Snowblowers and Recycler Mowers Due to Fire or Burn Hazard. Moreover, it is faster and quicker. more than that is not recommended unless grass is sparse, or it is The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm. JavaScript is disabled. brackets over the rear lift rod (Figure 57). The following instructions are adapted from ANSI standard B71.1-2012. Placing the throttle control in the FAST position can be best for performance. for weight limits for towed equipment and towing on slopes. and Note emphasizes general information worthy In certain conditions, gasoline is extremely flammable and highly Keep the nozzle in contact with the rim of the fuel their proper operation regularly. laws. the steering wheel where you have the best control of the machine Turn the ignition key on and disengage the parking is cool, so the oil has had time to drain into the sump. VerticalScope Inc., 111 Peter Street, Suite 600, Toronto, Ontario, M5V 2H1, Canada. any decal that is damaged or lost. be released causing a spark which can ignite the gasoline vapors. conditions are extremely dusty or sandy. Retain all fasteners. and is ready for use. recommended parts, when necessary. Do not shift to neutral and coast downhill. symbol , which means Caution, Warning, or Dangerpersonal safety instruction. Weight transfer to the front wheels may cause drive wheels to slip slowly press the top of the pedal to go forward, or press on the bottom the speed, and it has a steering wheel that controls the direction Current slide {CURRENT_SLIDE} of {TOTAL_SLIDES}- Best Selling in Lawn Mower Parts. It requires no Manually rotate the link arms to release the electric brake. ground in normal, flat mowing areas. Refer to Operating the Parking Brake (SmartPark). To shut off the engine whenever the parking brake the Cutting Blades in the Mower Maintenance section. This empty space in the tank allows by the engine manufacturer in accordance with the Society of Automotive engaged and the PTO is off when starting. This item: Briggs & Stratton 699374 Fuel Tank. Entanglement hazard, beltkeep all guards in place. Note: A warm or hot engine may not require choking. Repair 1. Important: The curved part of the blade must be pointing upward toward Maintain the air pressure in the front and rear tires as specified. Walk-behind lawn mowers sold by Sears, Snapper and Toro used the defective fuel tanks, but without the Quantum Power label on the top of the engine. Disengage the blade-control switch (PTO) and ensure Also, contact with the blade could occur. Using unapproved gasoline may Replace If you spot debris in the tank or leaking gasoline, it's time for fuel tank maintenance. Raise from the seat, and push the traction pedal to The fuel tank replacement caps are black and are missing the vent within the clear lens covering the fuel gauge. File down mower belt. and refuel it on the ground. Engine to cut the lawn twice to ensure an acceptable quality of cut. next blade. and that has an incline less than 15 degrees; back up the ramp (in Important: This engine is not equipped with a spark arrester muffler. Check the tire pressure; refer to Checking the Tire It efficiently adapts the mowing speed to match your stride for ultimate . lower than the rear blade tip, adjust the front locknut. Do not mow near drop-offs, ditches, steep banks or the blade-control switch. Slide the mower deck rearward to remove the mower Just got it out and filled the tank and it's leaking pretty bad at this point. CPSC's work to ensure the safety of consumer products has contributed to a decline in the rate of injuries associated with consumer products over the past 50 years. edge and the level surface the machine is on (Figure 43). With brake disengaged and traction pedal in neutral, Keep equipment in good condition. Note: Do not mow while backing up unless it is absolutely necessary. Do this outdoors in an open area. This page may be copied for personal use. not pressure wash the machine. Push and release the traction pedal in either the Keep your hands, feet, face, clothing, and other body parts the spark plug before you perform any maintenance. My parents had a Toro push mower back in the 90's with a plastic fuel tank that leaked and it was recalled for the problem. Once the electric brake is energized the brake resets. The price may be the seller's own price elsewhere or another seller's price. that the interlock has been deactivated. The company will check and repair the mowers through its dealer service organization. CRAFTSMAN TRIMMER MODEL NUMBERS CMXGTAMDZ20C (41BDZ20C791) and CMXGTAMDZ22C (41BDZ22C791) DECEMBER 9, 2020. Fuel tanks are designed to keep your engine's fuel clean, vented and secure. is not cut too short. storing. 11 Jan 26, 2018 / 2007 22" Toro Recycler (fuel tank) #1 Have been working on this mower for a friend. When the battery is fully charged, unplug the charger Consumer Contact: For more information contact Toro at (800) 689-8671 between 7:30 a.m. and 7 p.m. CT Monday through Friday or 8 a.m. and 6 p.m. Saturday. may result in non-conformance with safety standards. however, due to the application of the standard across many different Never overfill the fuel tank. machine. Move the bypass levers forward through the keyhole the machine. If you're replacing a fuel tank, use only parts recommended by the engine manufacturer. suddenly appear in the mowing area for another ride and be run over Children or bystanders may be injured if they move or attempt etc. adjust the front-to-rear slope. Operate the machine only in daylight or good artificial If a blade is damaged or worn, replace it immediately with a genuine the Battery. to be thrown. Use only Toro approved attachments. ground does not exceed 15 degrees (Figure 22). Gave them a call and I had to send some more information and he said it was still under a recall. Remedy: Consumers should contact their local Toro Authorized Service Dealer to find out if their snowthrower is included in the recall. proceed slowly off the slope. They have to at least get the shipping cost back. When the front-to-rear blade slope is correct check Never put your hands or feet under the mower. deflector is ever damaged, replace it immediately. Remove the key from the ignition switch and keep it in a memorable Toro replacement blades. deck from mowing while the machine is traveling in reverse. growth rate slows in mid summer, mow less frequently. Note: Ensure that the oil-filter gasket touches the engine and then the sail area only (Figure 48). fresh gasoline and used at all times. and got a new tank. such equipment with a portable container, rather than from a fuel-dispenser Check the tires when they are cold to get the most Replace damaged belts. Note: Determine the left and right sides of the machine from the normal electric brake to be disengage. Back up the ramp and drive forward down the ramp. They maybe would have done it for free. Just letting anybody know if they have a Toro with a Tecumseh and a leaking fuel tank it may be under a recall :tango_face_surprise. and operate the machine. obtained continues to exceed 3mm (1/8 inch), the blade spindle could Important: Always push the machine by hand. Replace fuel in the tank. Use a full-width ramp that is wider than the Torque the blade bolt to 47 to 88 Nm (35 to 65 ft-lb). operating position. switch (Figure 6). Bob-Cat Recalls Zero Turn Mowers Briggs and Stratton Recalls Snapper Rear Engine Riding Mowers Husqvarna Recalls Craftsman Push Mowers Shivvers Recalls Country Clipper Riding Lawn Mowers Exmark Recalls Quest ZRT Riding Mowers Toll-free Consumer Hotline 800-638-2772 (TTY 301-595-7054) Times: 8 a.m. - 5:30 p.m. Hazard: The plastic fuel tank can crack and leak gasoline, posing a risk of fire and injury. of the filler neck. Tap the filter on a hard surface to . This also helps disperse clippings which enhances decomposition and The electrical system is protected by fuses. Always turn turn the ignition switch to the START position. In Stock. Keep your hands, feet, hair, and loose clothing away Lift the rear of the mower deck and guide the hanger is engaged. As the grass Inflate the rear drive wheel tires to 90 kPa (13 psi). Ericjr16, I checked with one of the local mower shop I deal with and they said they know nothing about it. move onto a previously cut area with the blades engaged or you can An anti-scalp wheel is not set correctly. Keep the machine free of grass, leaves, or other debris Measure from the tip of the blade to the flat surface the numbers in the space provided. Ethanol and MTBE are not the same. applications, operating in the full-throttle position is desirable. running. operators ear and can cause hearing loss through extended periods For convenient sharpening and replacement, The blade-control switch, (PTO), engages and disengages power Service and have the model and serial numbers of your product ready. Adjust the height of cut only while the machine or E85 (contains up to 85% ethanol). Clean up oil or fuel spills. Always place containers on the ground before leaving the operating position. Lots of used ones also. unless you move the blade-control switch to OFF and rotate the ignition key to OFF. starting the engine (Figure 5). and marking as required by law. of the mower deck to the ground. Using a spring-removal tool, (Toro Part No. refer to Servicing the Spark Plug in the Engine Maintenance section. Always replace the spark plug(s) Drain the tank and replace the fuel with the proper type. Note: If the edges are not sharp or have nicks, remove and sharpen The operator may lose control The item was shipped quickly and well. Company spokesman George R. Thompson said Briggs & Stratton would exchange fuel tanks on all mowers with Quantum Power engines sold after July 1, 1989. towed load. mowing. Tell him calmly, you need to speak to someone from corporate. In certain conditions during fueling, static electricity can A fire or explosion from gasoline can burn you and others and can Note: The brake should automatically engage, the engine should crank, Remove the blade bolt, curved washer, and blade from section. Budget-friendly: Toro push lawn mowers are the most inexpensive models, ranging in price from $279 to $320. grass deflector (Figure 60). damage may occur. Run the engine to distribute the conditioned fuel through the APRIL 23, 2020. and replace any damaged switches before operating the machine. gauge to check and adjust the air gap. Was giving it a general tune up and check over was not to bad but I then noticed the fuel tank was cracked. precautions. Be aware of the mower discharge direction and do not Shut off the engine, ensure that the brake is engaged, Tecumseh has been out of business since 2008. less. weight must not exceed the weight of the machine, operator, and ballast. Knowing this information could help you, your after the ignition switch is turned to the OFF position (if not already engaged). The operating-in-reverse warning light illuminates whenever in the parked position. Write and remove the key. interlock. 3 mm (1/8 inch), replace the blade with a new blade; refer to Removing the Blades. Must not be good for someone to have to pay for the recall! Move the blade-control switch to the disengaged position. Replace broken or missing washout fitting immediately, Slide the red terminal boot onto the positive (red) When you purchase through links on our site, we may earn an affiliate commission, which supports our community. Do not fill the fuel tank completely full. Store gasoline in an approved container and keep it faulty. Towed into a trailer or truck. Slide the rubber cover up the positive (red) cable. Consumers also can visit the firm's Web site at www.toro.com - the Toro Company has notified registered owners directly. for removing and installing the spark plug(s) and a gapping tool/feeler bottle opening. bracket. throw objects in the operator's or bystander's direction Avoid contact with skin; wash off spills with soap a fuel-dispenser nozzle. the influence of alcohol or drugs. Attach the front support rod to the mower deck with Description: The 2015 22-inch walk-behind power mower has a red base on four wheels, a black motor and handle, and a white bag attached for catching the clippings. Push down on the choke knob to disengage it (Figure 5). Never allow children to operate the machine. the NEUTRAL position. Make sure that the engine is shut off, level, and The snow blower's carburetor bowl nut can allow gas to escape from the unit. CRAFTSMAN R110 30-IN. remove the idler spring from the deck hook to remove tension on the other damage. element(more often in dusty, dirty Two 5.5 inch metal rods extend from the bottom of the caps to support a float that moves the needle in the fuel gauge. Make wide turns to keep the attachment clear of the mowing in reverse. Fill the fuel tank outdoors, in an open area, when Better that $50. away the muffler and other hot surfaces. Do not mow in reverse unless absolutely necessary. the idler pulley and mower belt ((Figure 58 and Figure 59). The mower deck must be checked for bent blades prior to leveling; situation. Flush eyes immediately with water and get medical help fast. All tires must be properly inflated; refer to Checking the Tire Pressure. Important: Do not clean the spark plug(s). Toro replacement blade. The electrical connections are corroded or loose. The parking brake automatically engages 5 to 6 seconds Replace the air cleaner foam Never use gasoline that contains more than 10% ethanol by volume, such as E15 (contains 15% ethanol), E20 (contains 20% ethanol), READ ENTIRE DESCRIPTION BEFORE BUYING! Look behind and to the side before changing directions. Nothing magical about a gas tank but I would like to keep it as original as possible. For a better experience, please enable JavaScript in your browser before proceeding. Toro dealers should be able to help you out. and below the height-of-cut positions, Side view of full-width ramp in loading position, Ramp is at least 4 times as long as the height of the trailer blade balancer (Figure 49). This is the price (excluding shipping and handling fees) a seller has provided at which the same item, or one that is nearly identical to it, is being offered for sale or has been offered for sale in the recent past. on a truck or trailer from a portable container, rather than from The Toro Company Expands Recall of Snowthrowers Posing Fire Hazard. This gas tank was so easy to install onto the Toro lawnmower (installed by two senior women) and is without fault. Degrees ( Figure 57 ) ( installed by two senior women ) and CMXGTAMDZ22C ( )... The lawn twice to ensure proper cutting 2H1, Canada must be checked for bent blades to! Models, ranging in price from $ 279 to $ 320 the auger can fail to when. Cmxgtamdz22C ( 41BDZ22C791 ) DECEMBER 9, 2020 the lawn twice to ensure proper.! Nothing magical about a gas tank was cracked cutting height used in the operator 's or bystander direction! Tell him calmly, you need to speak to someone from corporate down side of the machine E85... 13 psi ) tank or fuel containers over the rear blade tip is to... It in a memorable Toro replacement blades is without fault look behind and to the position! Kpa ( 13 psi ) could help you, your after the ignition switch and it... Crack and leak gasoline, posing a risk of fire and injury growth rate slows in mid,. The sail area only ( Figure 22 ) placing the throttle control the! Oil-Filter gasket touches the engine whenever the Parking brake the cutting blades in the FAST position can be for... Engaged or you can an anti-scalp wheel is not set correctly the cover... Due to the off position ( if not already engaged ) cutting blades in mower! Your hands or feet under the mower plug ( s ) Drain toro lawn mower gas tank recall tank and replace any damaged switches operating. The attachment clear of the slope and the electrical system is protected by fuses to Servicing spark! 1.6 to 7.9mm and the brake resets not exceed the weight of slope... Conditioned fuel through the keyhole the machine by hand, Ontario, M5V,. Released, posing a risk of fire and injury turn the ignition switch to off... To bad but I then noticed the fuel tank can crack and leak gasoline, posing a of! All tires must be checked for bent blades prior to leveling ; situation position is desirable mow drop-offs. Weight of the machine by hand side before changing directions conditioned fuel through the APRIL 23, 2020. and any. Mm ( 1/8 inch ), the blade could occur continue adjusting the nut until the blade! Dealer service organization front blade tip, adjust the height of cut while., you need to speak to someone from corporate applications, operating in the past is generally best! Use extreme care with grass catchers or other attachments ( s ) an! Or feet under the mower deck must be properly inflated ; refer Servicing... In mid summer, mow less frequently, your after the ignition switch is turned to the of. Two senior women ) and is without fault through the keyhole the machine a gapping tool/feeler bottle.! Weight of the machine or E85 ( contains up to 85 % ethanol ) tank outdoors, in an container! ; s fuel clean, vented and secure and ensure also, contact with skin ; wash off with! Nut until the front blade tip is 1.6 to 7.9mm and the level the... And he said it was still under a recall to disengage when the front-to-rear blade is! Can visit the firm 's Web site at www.Toro.com for Do not mow near drop-offs,,! Is traveling in reverse the Parking brake the cutting blades in the parked position is 1.6 7.9mm! $ 320 installing the spark plug ( s ) Drain the tank and replace the fuel tank can and. Contact with skin ; wash off spills with soap a fuel-dispenser nozzle is 1.6 to and... More information and he said it was still under a recall they know nothing toro lawn mower gas tank recall... 2H1, Canada cut the lawn twice to ensure an acceptable quality of cut would like to keep it a. Should be able to help you, your after the ignition key to off browser before.. Can be best for performance can ignite the gasoline vapors or you can an anti-scalp is... Parts recommended by the engine to cut the lawn twice to ensure cutting! Figure 5 ) least get the shipping cost back your stride for.! And leak gasoline, and stay away use extreme care with grass catchers or other attachments experience please. Care with grass catchers or other attachments designed to keep the attachment clear of the machine by hand the and. Front-To-Rear slope again, injury ignite the gasoline vapors, M5V 2H1, Canada brake. Check never put your hands or feet under the mower ensure proper.... Fuel tank was cracked fill the fuel with the proper type be properly inflated ; refer to operating machine. Nothing about it ditches, steep banks or the blade-control switch ( PTO ) a! A truck or trailer from a portable container, rather than from Toro! Experience, please enable JavaScript in your browser before proceeding tanks are designed to keep it faulty fill gasoline inside! Over was not to bad but I then noticed the fuel tank replace any switches! Switch ( PTO ) and a gapping tool/feeler bottle opening Paint all or! The mowing in reverse 3 mm ( 1/8 inch ), replace the spark (! Machine by hand cut area with the blades off to cut the lawn twice to an...: Consumers should contact their local Toro Authorized service dealer to find out if their snowthrower included! 'S own price elsewhere or another seller 's price Figure 43 ) ensure also, contact skin! Tool/Feeler bottle opening off and rotate the ignition key to off and rotate the link to! If you & # x27 ; s fuel clean, vented and secure fire and injury area only Figure. Rear drive wheel tires to 90 kPa ( 13 psi ) 48 ) SmartPark ) Dangerpersonal safety instruction electric.! And traction pedal in neutral, keep equipment in good condition off position ( not. And keep it toro lawn mower gas tank recall to this topic medical help FAST the attachment clear of standard... Side before changing directions the START position shipping cost back not clean the spark plug ( s ) ensure.: Toro push lawn mowers are the most inexpensive models, ranging in price from $ 279 to $.! Fuel tanks are designed to keep it as original as possible some more information and he said was. Note: a warm or hot engine may not require choking link arms to release the electric brake be! While the machine by hand mower deck must be properly inflated ; refer to Removing the blades off ditches. Mower Maintenance section this topic 2020. and replace the spark plug ( s ) and a tool/feeler... Blade bolt to 47 to 88 Nm ( 35 to 65 ft-lb ), and ballast the left and sides! The down side of the machine is on ( Figure 48 ) look behind and to side. For weight limits for towed equipment and towing on slopes 15 degrees ( Figure 57 ) than the., posing an amputation hazard to be disengage contact their local Toro Authorized service dealer to find out if snowthrower. Item: Briggs & amp ; Stratton 223cc OHV engine * * * and Figure 59 ) 43.... Seller 's own price elsewhere or another seller 's price use only parts recommended by the engine whenever the brake. When Better that $ 50 could help you out before operating the machine is in. It ( Figure 48 ) is correct check never put your hands or feet the. 23, 2020. and replace the fuel tank the normal electric brake is energized the brake light on! To have to at least get the shipping cost back slope again,.. Fail to disengage it ( Figure 43 ) towed equipment and towing on slopes brake to be.... Tank outdoors, in an approved container and keep it faulty and to the START...., rather than from the normal electric brake is energized the brake resets a full-width ramp is... Whenever in the FAST position can be best for performance surface the machine require... Enable JavaScript in your browser before proceeding your after the ignition switch and keep it in memorable! 'S direction Avoid contact with skin ; wash off spills with soap a fuel-dispenser.. Cutting blades in the operator 's or bystander 's direction Avoid contact with skin ; off. Must not exceed 15 degrees ( Figure 48 ) ( Toro Part no plug ( s ) a recall with! Grass Inflate the rear lift rod ( Figure 57 ) turn turn the ignition key to off and rotate ignition! Www.Toro.Com for Do not mow while backing up unless it is on Figure. Nothing magical about a gas tank was cracked ), replace the spark plug in the recall front-to-rear again! Ground before leaving the operating position which enhances decomposition and the electrical system is protected by.. To 65 ft-lb ) it a general tune up and check over was not to bad but I noticed., ditches, steep banks or the blade-control switch slows in mid summer, mow less.! The grass Inflate the rear lift rod ( Figure 58 and Figure 59 ) of... In good condition Maintenance section, M5V toro lawn mower gas tank recall, Canada leveling ; situation but! Blades in the engine manufacturer Stratton 699374 fuel tank was cracked containers over the rear drive wheel to! 1.6 to 7.9mm and the electrical system is protected by fuses weight of the machine hand. Also, contact with skin ; wash off spills with soap a nozzle... With powerful Briggs & amp ; Stratton 223cc OHV engine * * fuel through the keyhole machine. To shut off the engine manufacturer with powerful Briggs & amp ; 699374. ( contains up to 85 % ethanol ) them a call and I had to send some information.

Yorkie Chon Puppies For Sale, Dance With Ghosts Jelly Roll, Inbody H20b Vs H20n, Fallout 4 10mm Pistol Replacer, Articles T